Service Fuel Sysytem warning - Cadillac XLR Forum: XLR and XLR-V Forums
LinkBack Thread Tools Display Modes
post #1 of 5 (permalink) Old 07-21-2012, 11:18 AM Thread Starter
Join Date: Aug 2011
Posts: 4
Service Fuel Sysytem warning

Yesterday on my 2007 XLR the driver info center started warning "Service Fuel System", and gas gauge read empty, but when I toggled through the info center it still was able to give me "miles to empty" amount, and it changed as I drove, including resetting to 300miles plus after I filled tank, so I believe it can read the amount of gas. When I start the car, the gauge sweeps to full as always, but then drops back to empty, and warning returns. I brought it to a GM Cadillac dealer today, and they are saying I need both fuel pumps, etc at over $3,300. Seems crazy since car works fine and computer can tell me how many miles to empty. Anybody else experience this. my direct email is Thanks for any ideas, etc.

Lance Joseph is offline  
Sponsored Links
post #2 of 5 (permalink) Old 07-21-2012, 05:11 PM
XLR I FL's Avatar
Join Date: Oct 2003
Location: Ponte Vedra, FL
Posts: 1,948


Sorry about your problems.

This bulletin covers the 2004 XLR but appears to be the same issue.

See if there is another one for your car on the site.


XLR I FL is offline  
post #3 of 5 (permalink) Old 07-21-2012, 05:24 PM
ccclarke's Avatar
Join Date: Mar 2008
Location: New England '13 XTS Platinum
Posts: 1,087
The dealership should have provided you with a sheet detailing what symptoms you provided, what testing they conducted, what the results were, and the recommended fix. Post that info and then a better answer can be given here.

There is only one (venturi-style) fuel pump, located in the left tank. Pressure from this is used to activate a siphon pump in the right tank. Both units are pretty reliable and based on the proven, two tank Corvette design. The fuel system is a PITA to service, since the integrated sender units are in each tank, along with the fuel filter. There's a lot of interference to remove, which accounts for a higher than average labor rate. This problem could be caused by a bad sender unit, but without test result codes, it's just logical guessing on my part.


Last edited by ccclarke; 07-21-2012 at 05:35 PM.
ccclarke is offline  
post #4 of 5 (permalink) Old 07-21-2012, 09:27 PM Thread Starter
Join Date: Aug 2011
Posts: 4
Thanks for the response. I should have listed the two codes that were found. They are P2066 and P2636, which are Fuel level sender B and Fuel Pump B, which as I understand refer to the 10psi transfer pump from the left to right tanks. When filled, it took 11 gallons, so it is transferring on fill, leading me to to believe both pumps are still working fine. A Corvette service tech mentioned that it sounds similar to a Vette issue which is usually repaired by replacing a wire from the B fuel sensor, and suggested that I try a Chevy dealership that may have had more experience doing it on Vettes, and that only one tank had to be dropped, unless I got lucky and it was a loose connector on the top of the tank that could be easily re-connected while on a lift
Lance Joseph is offline  
post #5 of 5 (permalink) Old 11-20-2012, 02:02 AM
Join Date: Mar 2010
Location: Michigan
Posts: 20
Did this get resolved? I just had the same thing happen to my 08 XLR-V,, "service fuel system" in DIC and gas gauge says empty, this happened with about 1/4 tank. Filled it and added some fuel system/injector cleaner as well,, nothing changed. It seems like I read this is because of a stored DTC code? And "clearing"? the codes might correct it? if only for awhile? If so, how do I clear any stored codes???? unhook battery? if so how long?

awaterworld is offline  
Sponsored Links

Quick Reply

Register Now

In order to be able to post messages on the Cadillac XLR Forum: XLR and XLR-V Forums forums, you must first register.
Please enter your desired user name, your email address and other required details in the form below.

User Name:
Please enter a password for your user account. Note that passwords are case-sensitive.


Confirm Password:
Email Address
Please enter a valid email address for yourself.

Email Address:


Human Verification

In order to verify that you are a human and not a spam bot, please enter the answer into the following box below based on the instructions contained in the graphic.

Currently Active Users Viewing This Thread: 1 (0 members and 1 guests)
Thread Tools
Show Printable Version Show Printable Version
Email this Page Email this Page
Display Modes
Linear Mode Linear Mode

Posting Rules  
You may post new threads
You may post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off
Trackbacks are On
Pingbacks are On
Refbacks are On

For the best viewing experience please update your browser to Google Chrome